Catalogs > Industrial Controls Catalog > Motor Control, IEC > Open Type Starters > Bulletin 190/191E Eco and Bulletin 190/191S Compact Combination Starters > Bulletin 190/191S Compact Combination Starters
Bulletin 190/191S Compact Combination Starters
Bulletin 190S Direct On-Line Compact Starters
|
|
- 190S Compact Starter using Bulletin 140M Motor Protection Circuit Breaker and Bulletin 100-C Contactor
- Short-Circuit Coordination Type "1" and "2" according to IEC 60947-4-1
- Complete unit, ready for connection with internal wiring
- Accessories: Bulletin 140M Circuit Breakers and 100-C Contactors
- Removable cover
- IEC and cULus Certified
- Auxiliary Contacts Wired to Terminal Block at Bottom of Starter Assembly
- Mounting Versions:
- Screw Fixing
- Snap Fixing on (1) or (2) 35 mm top hat rails
- Snap Fixing on (1) 75 mm top hat rail
|
|
Group Motor, Type E and Type F Combination Motor Controllers (UL/CSA)
The 190S/191S motor controllers can be used in a variety of applications. These starters can be used in a group motor application or as a stand alone product without any additional short-circuit protection in the motor branch circuits.
Most of the 140M-C/D motor protection circuit breakers used in the 190S/191S starters are UL Listed as a manual Type E self-protected combination motor controller. Although there are many tests involved, one of the critical tests a self-protected combination motor controller must pass, is to perform 6000 electrical ops. and an additional 4000 mechanical ops. after a short circuit.
By definition, a Type F combination motor controller consists of a Type E manual self protected combination motor controller and a magnetic or solid-state motor controller (such as a 100-C contactor or an SMC). As with a manual Type E self-protected combination motor controller, additional short-circuit protection is not required for the individual motor circuits.
A combination of a 140M manual self protected combination motor controller and 100-C contactor can be listed as a Type E self-protected combination motor controller. In this case, the 140M and 100-C must pass the additional 6000 electrical and 4000 mechanical operational test. In some cases, this may require over sizing of the 140M motor protection circuit breaker or the 100-C contactor to achieve weld-free performance and meet the additional life requirements.
Note: Verify that the motor protection circuit breaker can be set to the rated motor current.
Product Selection and Coordination Ratings — UL/CSA in Group Motor Installations
| Motor Current Adjustment Range [A] | UL/CSA Hp Ratings (60 Hz) | Max. Fuse or Circuit Breaker per NEC [A] | Max. Short-Circuit Current [kA] | DOL Starter | Reversing Starter (AC coils only) |
||||||
| Hp Ratings as a UL508 Motor Controller in Group Motor Installations§ | Type 1 Coordination | Type 2 Coordination | |||||||||
| 200V | 230V | 460V | 575V | 480V | 600V | 480V | 600V | Cat. No. | Cat. No. | ||
| C-Frame with Bulletin 100-C/104-C Contactors | |||||||||||
| 0.10…0.16 | — | — | — | — | 450 | 65 | 47 | 65 | 47 | 190S-ANÄ2-CA16C | 191S-ANÄ3-CA16C |
| 0.16…0.25 | — | — | — | — | 450 | 65 | 47 | 65 | 47 | 190S-ANÄ2-CA25C | 191S-ANÄ3-CA25C |
| 0.25…0.40 | — | — | — | — | 450 | 65 | 47 | 65 | 47 | 190S-ANÄ2-CA40C | 191S-ANÄ3-CA40C |
| 0.40…0.63 | — | — | — | — | 450 | 65 | 47 | 65 | 47 | 190S-ANÄ2-CA63C | 191S-ANÄ3-CA63C |
| 0.63…1.00 | — | — | 1/2 | 3/4 | 450 | 65 | 47 | 65 | 47 | 190S-ANÄ2-CB10C | 191S-ANÄ3-CB10C |
| 1.00…1.60 | — | — | 1/2…1 | 3/4...1 | 450 | 65 | 47 | 65 | 47 | 190S-ANÄ2-CB16C | 191S-ANÄ3-CB16C |
| 1.60…2.50 | 1/2 | 1/2...3/4 | 3/4…1-1/2 | 1…2 | 450 | 65 | 30 | 65 | 10 | 190S-ANÄ2-CB25C | 191S-ANÄ3-CB25C |
| 2.50…4.00 | 1/2…1 | 3/4...1 | 1-1/2…3 | 2…3 | 450 | 65 | 30 | 50 | — | 190S-ANÄ2-CB40C | 191S-ANÄ3-CB40C |
| 4.00…6.30 | 1...1-1/2 | 1…2 | 3...5 | 5 | 450 | 65 | 30 | 50 | — | 190S-ANÄ2-CB63C | 191S-ANÄ3-CB63C |
| 6.30…9.00 | 1-1/2…2 | 2 | 5 | 7-1/2 | 450 | 65 | 30 | 50 | — | 190S-ANÄ2-CC10C | 191S-ANÄ3-CC10C |
| 6.30…10.0 | 1-1/2…3 | 2...3 | 5...7-1/2 | 7-1/2...10 | 450 | 65 | 30 | 50 | — | 190S-BNÄ2-CC10C | 191S-BNÄ3-CC10C |
| 10.0…12.0 | 3 | 3 | 7-1/2 | 10 | 450 | 30 | 30 | — | — | 190S-BNÄ2-CC16C | 191S-BNÄ3-CC16C |
| 10.0…16.0 | 3...5 | 5 | 7-1/2…10 | 10 | 450 | 30 | 30 | — | — | 190S-CNÄ2-CC16C | 191S-CNÄ3-CC16C |
| 10.0…16.0 | 3...5 | 5 | 7-1/2…10 | 10...15 | 450 | 30 | 30 | — | — | 190S-DNÄ2-CC16C | 191S-DNÄ3-CC16C |
| 14.5…20.0 | 5 | 5...7-1/2 | 15 | 15 | 450 | 30 | 30 | — | — | 190S-DNÄ2-CC20C | 191S-DNÄ3-CC20C |
| 18.0…23.0 | 5 | 7-1/2 | 15 | 15 | 450 | 30 | 30 | — | — | 190S-DNÄ2-CC25C | 191S-DNÄ3-CC25C |
| D-Frame with Bulletin 100-C/104-C Contactors | |||||||||||
| 1.60…2.50 | 1/2 | 1/2...3/4 | 3/4…1-1/2 | 1…2 | 450 | 65 | 30 | 65 | 10 | 190S-ANÄ2-DB25C | 191S-ANÄ3-DB25C |
| 1.60…2.50 | 1/2 | 1/2...3/4 | 3/4…1-1/2 | 1…2 | 450 | 65 | 30 | 65 | 30 | 190S-DNÄ2-DB25C | 191S-DNÄ3-DB25C |
| 2.50…4.00 | 1/2…1 | 3/4...1 | 1-1/2…3 | 2…3 | 450 | 65 | 30 | 65 | — | 190S-ANÄ2-DB40C | 191S-ANÄ3-DB40C |
| 2.50…4.00 | 1/2…1 | 3/4...1 | 1-1/2…3 | 2…3 | 450 | 65 | 30 | 65 | 30 | 190S-DNÄ2-DB40C | 191S-DNÄ3-DB40C |
| 4.00…6.30 | 1…1-1/2 | 1…2 | 3…5 | 5 | 450 | 65 | 30 | 65 | — | 190S-ANÄ2-DB63C | 191S-ANÄ3-DB63C |
| 6.30…9.00 | 1-1/2…2 | 2 | 5 | 7-1/2 | 450 | 65 | 30 | 65 | — | 190S-ANÄ2-DC10C | 191S-ANÄ3-DC10C |
| 6.30…10.0 | 1-1/2…3 | 2...3 | 5…7-1/2 | 7-1/2…10 | 450 | 65 | 30 | 65 | — | 190S-BNÄ2-DC10C | 191S-BNÄ3-DC10C |
| 6.30…10.0 | 1-1/2…3 | 2...3 | 5…7-1/2 | 7-1/2…10 | 450 | 65 | 30 | 65 | — | 190S-CNÄ2-DC10C | 191S-CNÄ3-DC10C |
| 10.0…12.0 | 3 | 3 | 7-1/2 | 10 | 450 | 65 | 30 | 65 | — | 190S-BNÄ2-DC16C | 191S-BNÄ3-DC16C |
| 10.0…16.0 | 3…5 | 5 | 7-1/2…10 | 10 | 450 | 65 | 30 | 65 | — | 190S-CNÄ2-DC16C | 191S-CNÄ3-DC16C |
| 10.0…16.0 | 3…5 | 5 | 7-1/2…10 | 10…15 | 450 | 65 | 30 | 65 | — | 190S-DNÄ2-DC16C | 191S-DNÄ3-DC16C |
| 14.5…20.0 | 5 | 5...7-1/2 | 15 | 15 | 450 | 65 | 30 | 65 | — | 190S-DNÄ2-DC20C | 191S-DNÄ3-DC20C |
| 18.0…23.0 | 5 | 7-1/2 | 15 | 15 | 450 | 65 | 30 | 65 | — | 190S-DNÄ2-DC25C | 191S-DNÄ3-DC25C |
| F-Frame with Bulletin 100-C/104-C Contactors | |||||||||||
| 6.30…10.0 | 1-1/2…3 | 2...3 | 5…7-1/2 | 7-1/2…10 | 600 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC10C | — |
| 10.0…16.0 | 3…5 | 5 | 7-1/2…10 | 10…15 | 600 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC16C | — |
| 14.5…20.0 | 5 | 5…7-1/2 | 15 | 15…20 | 600 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC20C | — |
| 18.0…25.0 | 7-1/2 | 7-1/2...10 | 15...20 | 20 | 600 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC25C | — |
| 18.0…25.0 | 7-1/2 | 7-1/2...10 | 15...20 | 20...25 | 600 | 65 | 30 | 65 | 30 | 190S-GNÄ3-FC25C | — |
| 23.0…30.0 | 7-1/2 | 10 | 20 | 25 | 600 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC32C | — |
| 23.0…32.0 | 7-1/2...10 | 10 | 20...25 | 30 | 600 | 65 | 30 | 65 | 30 | 190S-FNÄ3-FC32C | — |
| 23.0…32.0 | 7-1/2...10 | 10 | 20...25 | 30 | 600 | 65 | 30 | 65 | 30 | 190S-GNÄ3-FC32C | — |
| 32.0…37.0 | 10 | 10 | 25 | 30 | 600 | 65 | 18 | 65 | 10 | 190S-FNÄ3-FC45C | — |
| 32.0…43.0 | 10 | 15 | 30 | 30 | 600 | 65 | 18 | 65 | 10 | 190S-GNÄ3-FC45C | — |
| § Hp ratings shown in the table are for reference. Final selection of the starter depends upon the actual motor full-load current. | |||||||||||
ÄCoil voltage code—see Ä Coil Voltage Codes for AC Control
Product Selection and Coordination Ratings — UL/CSA as a UL508 Type F Combination Motor Controller
| Motor Current Adjustment Range [A] | UL/CSA Hp Ratings (60 Hz) | Max. Short-Circuit Current [kA] | DOL Starter | Reversing Starter | ||||||
| Hp Ratings as a UL508 Type F Combination Motor Controller§ | Type 1 Coordination | Type 2 Coordination | ||||||||
| 200V | 230V | 460V | 575V | 480Y/277V | 600Y/347V | 480Y/277V | 600Y/347V | Cat. No. | Cat. No. | |
| C-Frame with Bulletin 100-C/104-C Contactors and Spacing Adapter | ||||||||||
| 0.10…0.16 | — | — | — | — | 65 | 47 | 65 | 47 | 190S-ANÄ2-CA16C-TE | 191S-ANÄ3-CA16C-TE |
| 0.16…0.25 | — | — | — | — | 65 | 47 | 65 | 47 | 190S-ANÄ2-CA25C-TE | 191S-ANÄ3-CA25C-TE |
| 0.25…0.40 | — | — | — | — | 65 | 47 | 65 | 47 | 190S-ANÄ2-CA40C-TE | 191S-ANÄ3-CA40C-TE |
| 0.40…0.63 | — | — | — | — | 65 | 47 | 65 | 47 | 190S-ANÄ2-CA63C-TE | 191S-ANÄ3-CA63C-TE |
| 0.63…1.00 | — | — | 1/2 | 3/4 | 65 | 47 | 65 | 47 | 190S-ANÄ2-CB10C-TE | 191S-ANÄ3-CB10C-TE |
| 1.00…1.60 | — | — | 1/2…1 | 3/4...1 | 65 | 47 | 65 | 47 | 190S-ANÄ2-CB16C-TE | 191S-ANÄ3-CB16C-TE |
| 1.60…2.50 | 1/2 | 1/2...3/4 | 3/4…1-1/2 | 1…2 | 65 | 30 | 65 | 10 | 190S-ANÄ2-CB25C-TE | 191S-ANÄ3-CB25C-TE |
| 2.50…4.00 | 1/2…1 | 3/4...1 | 1-1/2…3 | 2…3 | 65 | 30 | — | — | 190S-ANÄ2-CB40C-TE | 191S-ANÄ3-CB40C-TE |
| 4.00…6.30 | 1...1-1/2 | 1…2 | 3...5 | — | 65 | v | — | v | 190S-ANÄ2-CB63C-TE | 191S-ANÄ3-CB63C-TE |
| 6.30…9.00 | 1-1/2…2 | 2 | 5 | — | 65 | v | — | v | 190S-ANÄ2-CC10C-TE | 191S-ANÄ3-CC10C-TE |
| 6.30…10.0 | 1-1/2…3 | 2...3 | 5...7-1/2 | — | 65 | v | — | v | 190S-BNÄ2-CC10C-TE | 191S-BNÄ3-CC10C-TE |
| 10.0…12.0 | 3 | 3 | 7-1/2 | — | 30 | v | — | v | 190S-BNÄ2-CC16C-TE | 191S-BNÄ3-CC16C-TE |
| 10.0…16.0 | 3...5 | 5 | 7-1/2…10 | — | 30 | v | — | v | 190S-CNÄ2-CC16C-TE | 191S-CNÄ3-CC16C-TE |
| 10.0…16.0 | 3...5 | 5 | 7-1/2…10 | — | 30 | v | — | v | 190S-DNÄ2-CC16C-TE | 191S-DNÄ3-CC16C-TE |
| 14.5…20.0 | 5 | 5...7-1/2 | 15 | — | 10 | v | — | v | 190S-DNÄ2-CC20C-TE | 191S-DNÄ3-CC20C-TE |
| 18.0…23.0 | — | — | — | — | v | v | v | v | 190S-DNÄ2-CC25C-TE | 191S-DNÄ3-CC25C-TE |
| D-Frame with Bulletin 100-C/104-C Contactors and Spacing Adapter | ||||||||||
| 1.60…2.50 | 1/2 | 1/2...3/4 | 3/4…1-1/2 | 1…2 | 65 | 30 | 65 | 10 | 190S-ANÄ2-DB25C-TE | 191S-ANÄ3-DB25C-TE |
| 1.60…2.50 | 1/2 | 1/2...3/4 | 3/4…1-1/2 | 1…2 | 65 | 30 | 65 | 30 | 190S-DNÄ2-DB25C-TE | 191S-DNÄ3-DB25C-TE |
| 2.50…4.00 | 1/2…1 | 3/4...1 | 1-1/2…3 | 2…3 | 65 | 30 | 65 | — | 190S-ANÄ2-DB40C-TE | 191S-ANÄ3-DB40C-TE |
| 2.50…4.00 | 1/2…1 | 3/4...1 | 1-1/2…3 | 2…3 | 65 | 30 | 65 | 30 | 190S-DNÄ2-DB40C-TE | 191S-DNÄ3-DB40C-TE |
| 4.00…6.30 | 1…1-1/2 | 1…2 | 3…5 | 5 | 65 | 30 | 65 | — | 190S-ANÄ2-DB63C-TE | 191S-ANÄ3-DB63C-TE |
| 6.30…9.00 | 1-1/2…2 | 2 | 5 | 7-1/2 | 65 | 30 | 65 | — | 190S-ANÄ2-DC10C-TE | 191S-ANÄ3-DC10C-TE |
| 6.30…10.0 | 1-1/2…3 | 2...3 | 5…7-1/2 | 7-1/2…10 | 65 | 30 | 65 | — | 190S-BNÄ2-DC10C-TE | 191S-BNÄ3-DC10C-TE |
| 6.30…10.0 | 1-1/2…3 | 2...3 | 5…7-1/2 | 7-1/2…10 | 65 | 30 | 65 | — | 190S-CNÄ2-DC10C-TE | 191S-CNÄ3-DC10C-TE |
| 10.0…12.0 | 3 | 3 | 7-1/2 | 10 | 65 | 30 | 65 | — | 190S-BNÄ2-DC16C-TE | 191S-BNÄ3-DC16C-TE |
| 10.0…16.0 | 3…5 | 5 | 7-1/2…10 | 10 | 65 | 30 | 65 | — | 190S-CNÄ2-DC16C-TE | 191S-CNÄ3-DC16C-TE |
| 10.0…16.0 | 3…5 | 5 | 7-1/2…10 | 10…15 | 65 | 30 | 65 | — | 190S-DNÄ2-DC16C-TE | 191S-DNÄ3-DC16C-TE |
| 14.5…20.0 | 5 | 5...7-1/2 | 15 | — | 65 | v | 65 | v | 190S-DNÄ2-DC20C-TE | 191S-DNÄ3-DC20C-TE |
| 18.0…23.0 | 5 | 7-1/2 | 15 | — | 65 | v | 65 | v | 190S-DNÄ2-DC25C-TE | 191S-DNÄ3-DC25C-TE |
| F-Frame with Bulletin 100-C/104-C Contactors and Spacing Adapter | ||||||||||
| 6.30…10.0 | 1-1/2…3 | 2...3 | 5…7-1/2 | 7-1/2…10 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC10C-TE | — |
| 10.0…16.0 | 3…5 | 5 | 7-1/2…10 | 10…15 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC16C-TE | — |
| 14.5…20.0 | 5 | 5…7-1/2 | 15 | 15…20 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC20C-TE | — |
| 18.0…25.0 | 7-1/2 | 7-1/2...10 | 15...20 | 20 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC25C-TE | — |
| 18.0…25.0 | 7-1/2 | 7-1/2...10 | 15...20 | 20...25 | 65 | 30 | 65 | 30 | 190S-GNÄ3-FC25C-TE | — |
| 23.0…30.0 | 7-1/2 | 10 | 20 | 25 | 65 | 30 | 65 | 30 | 190S-ENÄ3-FC32C-TE | — |
| 23.0…32.0 | 7-1/2...10 | 10 | 20...25 | 30 | 65 | 30 | 65 | 30 | 190S-FNÄ3-FC32C-TE | — |
| 23.0…32.0 | 7-1/2...10 | 10 | 20...25 | 30 | 65 | 30 | 65 | 30 | 190S-GNÄ3-FC32C-TE | — |
| 32.0…37.0 | 10 | 10 | 25 | — | 65 | v | 65 | v | 190S-FNÄ3-FC45C-TE | — |
| 32.0…43.0 | 10 | 15 | 30 | — | 65 | v | 65 | v | 190S-GNÄ3-FC45C-TE | — |
| § Hp ratings shown in the table are for reference. Final selection of the starter depends upon the actual motor full-load current. | ||||||||||
| v This starter is not valid for application at this horsepower and voltage. | ||||||||||
ÄCoil voltage code—see Ä Coil Voltage Codes for AC Control
Product Selection and Coordination Ratings — UL/CSA as a UL508 Self-Protected Type E Combination Motor Controller
| Motor Current Adjustment Range [A] | UL/CSA Hp Ratings (60 Hz) | Max. Short-Circuit Current [kA] | DOL Starter | Reversing Starter | ||||
| Hp Ratings as a UL508 Self-Protected Type E Combination Motor Controller§ | ||||||||
| 200V | 230V | 460V | 575V | 480Y/277V | 600Y/347V | Cat. No. | Cat. No. | |
| C-Frame with Bulletin 100-C/104-C Contactors and Spacing Adapter | ||||||||
| 0.10…0.16 | — | — | — | — | 65 | 47 | 190S-ANÄ2-CA16C-TE | 191S-ANÄ3-CA16C-TE |
| 0.16…0.25 | — | — | — | — | 65 | 47 | 190S-ANÄ2-CA25C-TE | 191S-ANÄ3-CA25C-TE |
| 0.25…0.40 | — | — | — | — | 65 | 47 | 190S-ANÄ2-CA40C-TE | 191S-ANÄ3-CA40C-TE |
| 0.40…0.63 | — | — | — | — | 65 | 47 | 190S-ANÄ2-CA63C-TE | 191S-ANÄ3-CA63C-TE |
| 0.63…1.00 | — | — | 1/2 | 3/4 | 65 | 47 | 190S-ANÄ2-CB10C-TE | 191S-ANÄ3-CB10C-TE |
| 1.00…1.60 | — | — | 1/2…1 | 3/4...1 | 65 | 47 | 190S-ANÄ2-CB16C-TE | 191S-ANÄ3-CB16C-TE |
| 1.60…2.50 | 1/2 | 1/2...3/4 | 3/4…1-1/2 | — | 65 | v | 190S-ANÄ2-CB25C-TE | 191S-ANÄ3-CB25C-TE |
| 2.50…4.00 | — | — | — | — | v | v | 190S-ANÄ2-CB40C-TE | 191S-ANÄ3-CB40C-TE |
| 4.00…6.30 | — | — | — | — | v | v | 190S-ANÄ2-CB63C-TE | 191S-ANÄ3-CB63C-TE |
| 6.30…9.00 | — | — | — | — | v | v | 190S-ANÄ2-CC10C-TE | 191S-ANÄ3-CC10C-TE |
| 6.30…10.0 | — | — | — | — | v | v | 190S-BNÄ2-CC10C-TE | 191S-BNÄ3-CC10C-TE |
| 10.0…12.0 | — | — | — | — | v | v | 190S-BNÄ2-CC16C-TE | 191S-BNÄ3-CC16C-TE |
| 10.0…16.0 | — | — | — | — | v | v | 190S-CNÄ2-CC16C-TE | 191S-CNÄ3-CC16C-TE |
| 10.0…16.0 | — | — | — | — | v | v | 190S-DNÄ2-CC16C-TE | 191S-DNÄ3-CC16C-TE |
| 14.5…20.0 | — | — | — | — | v | v | 190S-DNÄ2-CC20C-TE | 191S-DNÄ3-CC20C-TE |
| 18.0…23.0 | — | — | — | — | v | v | 190S-DNÄ2-CC25C-TE | 191S-DNÄ3-CC25C-TE |
| D-Frame with Bulletin 100-C/104-C Contactors and Spacing Adapter | ||||||||
| 1.60…2.50 | 1/2 | 1/2...3/4 | 3/4…1-1/2 | — | 65 | v | 190S-ANÄ2-DB25C-TE | 191S-ANÄ3-DB25C-TE |
| 1.60…2.50 | 1/2 | 1/2...3/4 | 3/4…1-1/2 | 1…2 | 65 | 30 | 190S-DNÄ2-DB25C-TE | 191S-DNÄ3-DB25C-TE |
| 2.50…4.00 | — | — | — | — | v | v | 190S-ANÄ2-DB40C-TE | 191S-ANÄ3-DB40C-TE |
| 2.50…4.00 | 1/2…1 | 3/4...1 | 1-1/2…3 | 2…3 | 65 | 30 | 190S-DNÄ2-DB40C-TE | 191S-DNÄ3-DB40C-TE |
| 4.00…6.30 | — | — | — | — | v | v | 190S-ANÄ2-DB63C-TE | 191S-ANÄ3-DB63C-TE |
| 6.30…9.00 | — | — | — | — | v | v | 190S-ANÄ2-DC10C-TE | 191S-ANÄ3-DC10C-TE |
| 6.30…10.0 | — | — | — | — | v | v | 190S-BNÄ2-DC10C-TE | 191S-BNÄ3-DC10C-TE |
| 6.30…10.0 | — | — | — | — | v | v | 190S-CNÄ2-DC10C-TE | 191S-CNÄ3-DC10C-TE |
| 10.0…12.0 | — | — | — | — | v | v | 190S-BNÄ2-DC16C-TE | 191S-BNÄ3-DC16C-TE |
| 10.0…16.0 | — | — | — | — | v | v | 190S-CNÄ2-DC16C-TE | 191S-CNÄ3-DC16C-TE |
| 10.0…16.0 | — | — | — | — | v | v | 190S-DNÄ2-DC16C-TE | 191S-DNÄ3-DC16C-TE |
| 14.5…20.0 | — | — | — | — | v | v | 190S-DNÄ2-DC20C-TE | 191S-DNÄ3-DC20C-TE |
| 18.0…23.0 | — | — | — | — | v | v | 190S-DNÄ2-DC25C-TE | 191S-DNÄ3-DC25C-TE |
| F-Frame with Bulletin 100-C/104-C Contactors and Spacing Adapter | ||||||||
| 6.30…10.0 | 1-1/2…3 | 2...3 | 5…7-1/2 | 7-1/2…10 | 65 | 30 | 190S-ENÄ3-FC10C-TE | — |
| 10.0…16.0 | 3…5 | 5 | 7-1/2…10 | 10…15 | 65 | 30 | 190S-ENÄ3-FC16C-TE | — |
| 14.5…20.0 | 5 | 5…7-1/2 | 15 | 15…20 | 65 | 30 | 190S-ENÄ3-FC20C-TE | — |
| 18.0…25.0 | 7-1/2 | 7-1/2...10 | 15...20 | 20 | 65 | 30 | 190S-ENÄ3-FC25C-TE | — |
| 18.0…25.0 | 7-1/2 | 7-1/2...10 | 15...20 | 20...25 | 65 | 30 | 190S-GNÄ3-FC25C-TE | — |
| 23.0…30.0 | 7-1/2 | 10 | 20 | 25 | 65 | 30 | 190S-ENÄ3-FC32C-TE | — |
| 23.0…32.0 | 7-1/2...10 | 10 | 20...25 | 30 | 65 | 30 | 190S-FNÄ3-FC32C-TE | — |
| 23.0…32.0 | 7-1/2...10 | 10 | 20...25 | 30 | 65 | 30 | 190S-GNÄ3-FC32C-TE | — |
| 32.0…37.0 | 10 | 10 | 25 | — | 65 | v | 190S-FNÄ3-FC45C-TE | — |
| 32.0…43.0 | 10 | 15 | 30 | — | 65 | v | 190S-GNÄ3-FC45C-TE | — |
| § Hp ratings shown in the table are for reference. Final selection of the starter depends upon the actual motor full-load current. | ||||||||
| v This starter is not valid for application at this horsepower and voltage. | ||||||||
ÄCoil voltage code—see Ä Coil Voltage Codes for AC Control
Product Selection and Coordination Ratings—IEC Type 1 and Type 2 Short-Circuit Coordination
| Motor Current Adjustment Range [A] | IEC kW Ratings for Standard Motors, 1500 rpm | Max. Short-Circuit Current [kA] | DOL Starter | Reversing Starter | ||||||||||
| Max. kW, 50 Hz§ | Type 1 Coordination | Type 2 Coordination | ||||||||||||
| 230V | 400V | 500V | 690V | 230V | 400V | 500V | 690V | 230V | 400V | 500V | 690V | Cat. No. | Cat. No. | |
| C-Frame with Bulletin 100-C/104-C Contactors | ||||||||||||||
| 0.10…0.16 | — | — | 0.06 | 0.06 | 100 | 100 | 65 | 50 | 100 | 100 | 65 | 50 | 190S-ANÄ2-CA16C | 191S-ANÄ3-CA16C |
| 0.16…0.25 | 0.02 | 0.06 | 0.06 | 0.12 | 100 | 100 | 65 | 50 | 100 | 100 | 65 | 50 | 190S-ANÄ2-CA25C | 191S-ANÄ3-CA25C |
| 0.25…0.40 | 0.06 | 0.09 | 0.12 | 0.18 | 100 | 100 | 65 | 50 | 100 | 100 | 65 | 50 | 190S-ANÄ2-CA40C | 191S-ANÄ3-CA40C |
| 0.40…0.63 | 0.09 | 0.18 | 0.18 | 0.37 | 100 | 100 | 65 | 50 | 100 | 100 | 65 | 50 | 190S-ANÄ2-CA63C | 191S-ANÄ3-CA63C |
| 0.63…1.00 | 0.12 | 0.25 | 0.37 | 0.55 | 100 | 100 | 65 | 50 | 100 | 100 | 65 | 50 | 190S-ANÄ2-CB10C | 191S-ANÄ3-CB10C |
| 1.00…1.60 | 0.25 | 0.55 | 0.75 | 1.1 | 100 | 100 | 65 | 50 | 100 | 100 | 65 | 50 | 190S-ANÄ2-CB16C | 191S-ANÄ3-CB16C |
| 1.60…2.50 | 0.55 | 0.75 | 1.1 | 1.8 | 100 | 65 | 50 | 8 | 65 | 50 | 50 | 8 | 190S-ANÄ2-CB25C | 191S-ANÄ3-CB25C |
| 2.50…4.00 | 0.75 | 1.5 | 2.2 | 3 | 100 | 50 | 50 | 8 | 50 | 50 | — | — | 190S-ANÄ2-CB40C | 191S-ANÄ3-CB40C |
| 4.00…6.30 | 1.5 | 2.2 | 3 | 4 | 100 | 50 | 50 | 4 | 50 | 50 | — | — | 190S-ANÄ2-CB63C | 191S-ANÄ3-CB63C |
| 6.30…9.00 | 2.2 | 4 | 4 | — | 100 | 65 | 50 | — | 50 | 50 | — | — | 190S-ANÄ2-CC10C | 191S-ANÄ3-CC10C |
| 6.30…10.0 | 2.2 | 4 | 5.5 | 5.5 | 100 | 65 | 50 | 4 | 50 | 50 | 50 | — | 190S-BNÄ2-CC10C | 191S-BNÄ3-CC10C |
| 6.30…10.0 | 2.2 | 4 | 5.5 | 7.5 | 100 | 65 | 50 | 4 | 50 | 50 | 50 | — | 190S-CNÄ2-CC10C | 191S-BNÄ3-CC10C |
| 10.0…12.0 | 4 | 5.5 | — | — | 100 | 65 | — | — | 50 | 50 | — | — | 190S-BNÄ2-CC16C | 191S-BNÄ3-CC16C |
| 10.0…16.0 | 4 | 7.5 | 7.5 | — | 100 | 50 | 10 | — | 50 | — | — | — | 190S-CNÄ2-CC16C | 191S-CNÄ3-CC16C |
| 10.0…16.0 | 4 | 7.5 | 10 | 10 | 100 | 50 | 10 | 3 | 50 | 50 | — | — | 190S-DNÄ2-CC16C | 191S-DNÄ3-CC16C |
| 14.5…20.0 | 4 | 10 | 11 | — | 50 | 15 | 6 | — | 15 | — | — | — | 190S-DNÄ2-CC20C | 191S-DNÄ3-CC20C |
| 18.0…23.0 | 6.3 | 11 | 13 | — | 50 | 15 | 6 | — | 15 | — | — | — | 190S-DNÄ2-CC25C | 191S-DNÄ3-CC25C |
| D-Frame with Bulletin 100-C/104-C Contactors | ||||||||||||||
| 1.60…2.50 | 0.55 | 0.75 | 1.1 | 1.8 | 100 | 100 | 50 | 10 | 100 | 100 | 50 | 10 | 190S-ANÄ2-DB25C | 191S-ANÄ3-DB25C |
| 1.60…2.50 | 0.55 | 0.75 | 1.1 | 1.8 | 100 | 100 | 50 | 10 | 100 | 100 | 50 | 10 | 190S-DNÄ2-DB25C | 191S-DNÄ3-DB25C |
| 2.50…4.00 | 0.75 | 1.5 | 2.2 | 3 | 100 | 100 | 50 | 10 | 100 | 100 | 50 | — | 190S-ANÄ2-DB40C | 191S-ANÄ3-DB40C |
| 2.50…4.00 | 0.75 | 1.5 | 2.2 | 3 | 100 | 100 | 50 | 50 | 100 | 100 | 50 | 50 | 190S-DNÄ2-DB40C | 191S-DNÄ3-DB40C |
| 4.00…6.30 | 1.5 | 2.2 | 3 | 4 | 100 | 100 | 50 | 50 | 100 | 100 | 50 | — | 190S-ANÄ2-DB63C | 191S-ANÄ3-DB63C |
| 6.30…9.00 | 2.2 | 4 | 4 | — | 100 | 65 | 50 | — | 100 | 65 | — | — | 190S-ANÄ2-DC10C | 191S-ANÄ3-DC10C |
| 6.30…10.0 | 2.2 | 4 | 5.5 | 5.5 | 100 | 100 | 65 | 50 | 100 | 100 | 65 | — | 190S-BNÄ2-DC10C | 191S-BNÄ3-DC10C |
| 6.30…10.0 | 2.2 | 4 | 5.5 | 7.5 | 100 | 100 | 65 | 50 | 100 | 100 | 65 | 50 | 190S-CNÄ2-DC10C | 191S-CNÄ3-DC10C |
| 10.0…12.0 | 4 | 5.5 | — | — | 100 | 65 | — | — | 65 | 65 | — | — | 190S-BNÄ2-DC16C | 191S-BNÄ3-DC16C |
| 10.0…16.0 | 4 | 7.5 | 7.5 | — | 100 | 65 | 50 | — | 65 | 65 | 50 | — | 190S-CNÄ2-DC16C | 191S-CNÄ3-DC16C |
| 10.0…16.0 | 4 | 7.5 | 10 | 10 | 100 | 65 | 50 | 6 | 65 | 65 | 50 | — | 190S-DNÄ2-DC16C | 191S-DNÄ3-DC16C |
| 14.5…20.0 | 4 | 10 | 11 | — | 65 | 65 | 25 | — | 65 | 65 | 25 | — | 190S-DNÄ2-DC20C | 191S-DNÄ3-DC20C |
| 18.0…23.0 | 6.3 | 11 | 13 | — | 65 | 50 | 25 | — | 65 | 50 | 25 | — | 190S-DNÄ2-DC25C | 191S-DNÄ3-DC25C |
| F-Frame with Bulletin 100-C/104-C Contactors | ||||||||||||||
| 6.30…10.0 | 2.2 | 4 | 5.5 | 7.5 | 100 | 100 | 50 | 50 | 100 | 100 | 50 | 50 | 190S-ENÄ3-FC10C | — |
| 10.0…16.0 | 4 | 7.5 | 10 | 13 | 100 | 100 | 50 | 50 | 100 | 100 | 50 | 50 | 190S-ENÄ3-FC16C | — |
| 14.5…20.0 | 4 | 10 | 11 | 15 | 100 | 100 | 50 | 50 | 100 | 100 | 50 | 50 | 190S-ENÄ3-FC20C | — |
| 18.0…25.0 | 6.3 | 11 | 15 | — | 100 | 100 | 50 | — | 100 | 100 | 50 | — | 190S-ENÄ3-FC25C | — |
| 18.0…25.0 | 6.3 | 11 | 15 | 22 | 100 | 100 | 50 | 50 | 100 | 100 | 50 | 50 | 190S-GNÄ3-FC25C | — |
| 23.0…30.0 | 7.5 | 15 | 15 | — | 100 | 100 | 50 | — | 100 | 100 | 50 | — | 190S-ENÄ3-FC32C | — |
| 23.0…32.0 | 7.5 | 15 | 20 | — | 100 | 100 | 50 | — | 100 | 100 | 50 | — | 190S-FNÄ3-FC32C | — |
| 23.0…32.0 | 7.5 | 15 | 20 | 22 | 100 | 100 | 50 | 50 | 100 | 100 | 50 | 50 | 190S-GNÄ3-FC32C | — |
| 32.0…37.0 | 11 | 18.5 | — | — | 100 | 100 | — | — | 100 | 100 | — | — | 190S-FNÄ3-FC45C | — |
| 32.0…43.0 | 13 | 22 | 25 | — | 100 | 100 | 50 | — | 100 | 100 | 50 | — | 190S-GNÄ3-FC45C | — |
| § kW ratings shown in the table are for reference. Final selection of the starter depends upon the actual motor full-load current. | ||||||||||||||
ÄCoil voltage code—see Ä Coil Voltage Codes for AC Control
Bulletin 190S/191S Compact Combination Starters
Ä Coil Voltage Codes for AC Control
| [V] | 12 | 24 | 32 | 36 | 42 | 48 | 100 | 100- 110 |
110 | 120 | 127 | 200 | 200- 220 |
200- 230 |
208 | 208- 240 |
| AC, 50 Hz | R | K | V | W | X | Y | KP | — | D | P | S | KG | — | — | — | — |
| AC, 60 Hz | Q | J | — | V | — | X | — | KP | — | D | — | — | KG | — | H | L |
| AC, 50/60 Hz | — | KJ | — | — | — | KY | KP | — | KD | — | — | KG | — | KL | — | — |
| [V] | 220- 230 |
230 | 230- 240 |
240 | 277 | 347 | 380 | 380- 400 |
400 | 400- 415 |
440 | 480 | 500 | 550 | 600 | |
| AC, 50 Hz | F | — | VA | T | — | — | — | N | — | G | B | — | M | C | — | |
| AC, 60 Hz | — | — | — | A | T | I | E | — | — | — | N | B | — | — | C | |
| AC, 50/60 Hz | — | KF | — | KA | — | — | — | — | KN | — | KB | — | — | — | — | |
Ä Coil Voltage Codes for DC Control (Bulletin 190S only)
| [V] | 9 | 12 | 24 | 36 | 48 | 60 | 64 | 72 | 80 | 110 | 115 | 125 | 220 | 230 | 250 | |
| Standard | DC | ZR | ZQ | ZJ | ZW | ZY | ZZ | ZB | ZG | ZE | ZD | ZP | ZS | ZA | ZF | ZT |
| with Integrated Diode | — | — | DJ | — | — | — | — | — | — | — | — | — | — | — | — | |
| Electronic¬ | — | — | EJ | — | — | — | — | — | — | — | — | — | — | — | — | |
| ¬ Also available for Bulletin 191S starters. | ||||||||||||||||